Product ID:WHITE LITHIUM GREASE (AEROSOL), L6-16
MSDS Date:12/01/1998
FSC:NIIN:Submitter:N EN
Status Code:A
MSDS Number: CLMFN

RADIATOR SPECIALTY COMPANY

1900 WILKINSON BLVD.
CHARLOTTE, NC 28208
US

Emergency Phone: 303-623-5716

Info Phone: 704-377-6555/303-623-5716

Preparer: R. GEER - CHEMIST

Cage: 77628

RADIATOR SPECIALTY COMPANY

34689 CHARLOTTE, NC 28208 US

Telephone: 704-377-6555/303-623-5716

Cage: 77628

(HEPTANE, DIPROPYLMETHANE)

CAS: 142-82-5

RTECS: MI7700000

OSHA PEL 400 PPM

ACGIH TLV: 1640 MG/M3;400 PPM

PETROLEUM DISTILLATE (HEXANE)

CAS: 110-54-3

RTECS: MN9275000

OSHA PEL 500 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

BUTANE

CAS: 106-97-8

RTECS: EJ4200000

OSHA PEL 800 PPM

ACGIH TLV: 1900 MG/M3;800 PPM

PROPANE

CAS: 74-98-6

RTECS: TX2275000

OSHA PEL 1000 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: LIQUID OR VAPOR CAN CAUSE
MODERATE TO SEVERE IRRITATION. SKIN CONTACT: CONTACT MAY DRY SKIN;
PROLONGED CONTACT MAY CAUSE MODERATE IRRITATION. INHALATION: CAUSES
RESPIRATORY IRRITATION, HE ADACHE, NAUSEA, FATIGUE, DROWSINESS,
IMPAIRED COORDINATION. INGESTION: NOT LIKELY. HOWEVER, IF SWALLOWED
DO NOT INDUCE VOMITING. SEEK MEDICAL ATTENTION. OTHER : NOT KNOWN.
Effects of Overexposure:REFER TO HEALTH HAZARDS ACUTE AND CHRONIC .

First Aid:EYE CONTACT: WASH IMMEDIATELY WITH LARGE AMOUNTS OF FRESH
WATER FOR AT LEAST 15 MINUTES WHILE LIFTING EYELIDS. GET MEDICAL
ATTENTION. SKIN CONTACT: WIPE OFF WITH TOWEL. WASH WITH SOAP AND
WATER. GET M EDICAL ATTENTION IF IRRITATION PERSISTS. INHALATION:
REMOVE TO FRESH AIR. ADMINISTER OXYGEN IF NEEDED. APPLY ARTIFICIAL
RESPIRATION IF BREATHING HAS STOPPED. GET MEDICAL ATTENTION.
INGESTION: DO NOT I NDUCE VOMITING. GET MEDICAL ATTENTION
IMMEDIATELY.

Flash Point:=-104.4C, -156.F
ESTIMATE
Extinguishing Media:WATER FOG, FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SELF-CONTAINED, POSITIVE
PRESSURE BREATHING APPARATUS AND PROTECTIVE CLOTHES. WATER SPRAY
MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL CONTAINERS TO PREVENT
PRESSURE BUILD-UP AND EXPLOSION WHEN EXPOSED TO EXTREME HEAT. IF
WATER IS USED, FOG NOZZLES PREFERABLE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE FROM
INTERNAL PRESSURE BUILD-UP WHEN EXPOSED TO EXTREME HEAT AND
DISCHARGE CONTENTS. VAPOR ACCUMULATION CAN FLASH OR EXPLODE IF
IGNITED. OVEREXPOSURE TO DECOMPOSITION PRO DUCTS MAY CAUSE HEALTH
HAZARD. SYMPTOMS MAY NOT BE READILY APPARENT. OBTAIN MEDICAL
ATTENTION.

Spill Release Procedures:AVOID BREATHING VAPORS. VENTILATE AREA. REMOVE
IGNITION SOURCES. CLEAN AREA WITH ABSORBENT MATERIAL AND PLACE IN
CLOSED CONTAINERS FOR DISPOSAL.

Handling and Storage Precautions:STORE IN COOL, DRY, WELL-VENTILATED
AREAS. DO NOT STORE OVER 120F. DO NOT PUNCTURE OR INCINERATE (BURN)
CANS. DO NOT STICK PIN, NAIL OR OTHER SHARP OBJECT INTO OPENING ON
TOP OF CAN. SEE PRODUCT HAZAR DS.
Other Precautions:SMALL PRESSURIZED CONTAINERS OF FLAMMABLE PRODUCTS
MAY BE STORED IN AREAS SUITABLE FOR ORDINARY COMBUSTIBLES WITH
RESPECT TO CONSTRUCTION, DRAINAGE, CONTROL OF IGNITION SOURCES AND
VENTILATION. KEEP O UT OF REACH OF CHILDREN AND SMALL ANIMALS.

Respiratory Protection:NONE UNDER NORMAL USE. AVOID BREATHING VAPORS.
IN RESTRICTED AREAS USE NIOSH APPROVED AIRLINE TYPE RESPIRATOR OR
HOOD. NIOSH APPROVED SELF CONTAINED BREATHING APPRATUS IS REQUIRED
FOR VAPOR CONCENTRAT IONS OVER PEL/TLV LIMITS.
Ventilation:USE SUFFICIENT TO PREVENT INHAL.VAPOR CONCENTRATION ABOVE
PEL/TLV LIMITS WITH GENERAL/ LOCAL EXHAUST VENTILATION TO KEEP
BELOW PEL/TLV OF MOST HAZARDOUS INGRED.
Protective Gloves:SOLVENT RESISTANT GLOVES REQUIRED FOR PROLONGED OR
REPEATED CONTACT.
Eye Protection:USE ANSI APPROVED SAFETY GLASSES WITH SPLASH GUARDS OR
FULL FACE SHIELD.
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . USE OF SOLVENT RESISTANT APRONS OR OTHER CLOTHING
IS RECOMMENDED.
Work Hygienic Practices:N/P.
Supplemental Safety and Health
PHYSICAL PROPERTIES (CON'T): SOLUBILITY IN SOLVENT: DISPERSIBLE.

Boiling Pt:=-42.2C, -44.F
B.P. Text:-44F TO -208F
Solubility in Water:NIL
Appearance and Odor:CREAMY, OFF-WHITE GREASE WITH SOLVENT ODOR.
Percent Volatiles by Volume:80% APPROX

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY PRODUCE FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CARBON MONOXIDE.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
GOVERNMENT LAWS AND REGULATIONS. BEFORE ATTEMPTING CLEAN-UP, REFER
TO OTHER SECTIONS OF THIS MSDS FOR HAZARDS.

Toxicological Information:RECOMMENDED TLV OF PRODUCT: 400 PPM PETROLEUM
DISTILLATE (TEXTILE SPIRITS).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.